|
二维码（扫一下试试看！） |
| KH-550改性纳米Al2O3增强芳纶纸性能的研究 |
| Effect of Modified Nano- Al2O3 on Properties of Aramid Paper |
| 收稿日期： |
| DOI：10.11980/j.issn.0254-508X.2016.04.008 |
| 关键词: 芳纶纸 硅烷偶联剂 纳米Al2O3 性能 |
| Key Words:aramid paper silicon coupling agent nano- Al2O3 performance |
| 基金项目:陕西省2015科技统筹创新工程计划，项目编号2015KTCQO1-44；国家863项目子课题名称“粉煤灰提取氧化硅生产高填料文化用纸技术（2011AA06A101）”。 |
| 作者 | 单位 | | 张素风 | 陕西科技大学轻工与能源学院,陕西省造纸技术及特种纸品开发重点实验室,陕西西安，710021 | | 张美娟 | 陕西科技大学轻工与能源学院,陕西省造纸技术及特种纸品开发重点实验室,陕西西安，710021 | | 豆莞莞 | 陕西科技大学轻工与能源学院,陕西省造纸技术及特种纸品开发重点实验室,陕西西安，710021 | | 蒋莹莹 | 陕西科技大学轻工与能源学院,陕西省造纸技术及特种纸品开发重点实验室,陕西西安，710021 | | 李鹏辉 | 陕西科技大学轻工与能源学院,陕西省造纸技术及特种纸品开发重点实验室,陕西西安，710021 |
|
| 摘要点击次数: 6053 |
| 全文下载次数: 1802 |
| 摘要:采用不同用量的硅烷偶联剂（KH-550）对纳米Al2O3表面进行改性研究,采用红外光谱和粒度仪对改性前后纳米Al2O3进行表征；并考察了改性纳米Al2O3的用量对芳纶纸抗张强度、介电强度和紧度等性能的影响。结果表明,KH-550能够成功地对纳米Al2O3进行改性,并且有助于芳纶纸性能的增强。随着KH-550用量的增加,改性后的纳米Al2O3粒径有所减小；纳米Al2O3与KH-550最佳配比为5 g∶15 mL,改性纳米Al2O3用量为6%时,芳纶纸的抗张指数和介电强度分别提高了58.3%和37.0%,但纸张的紧度变化不明显。 |
| Abstract:Nano- Al2O3 particles were modified with four different amount of silicon coupling agent KH-550 and the modified nano- Al2O3 particle size was measured. At the same time, the effects of addition amount of modified nano- Al2O3 on tensile strength, dielectric strength, tightness properties of aramid paper were studied. The tensile strength and dielectric strength of the aramid paper before and after adding nano- Al2O3 were compared. The results showed that the nano- Al2O3 particle size was reduced after modification. When the ratio of nano- Al2O3 and silicon coupling agent KH-550 was 5 g∶15 mL, the amount of modified nano- Al2O3 was 6%, the tensile strength of the paper increased by 58.3%, the dielectric strength increased by 37.0%, the paper tightness did not change significantly. |
| 查看全文 HTML 查看/发表评论 下载PDF阅读器 |
|
|
|