棉短绒H<sub>2</sub>O<sub>2</sub>一步法蒸漂制浆的不足及对策

薛润林

二维码（扫一下试试看！）

棉短绒H₂O₂一步法蒸漂制浆的不足及对策

The Shortcomings and Solution of Cotton Linter Hydrogen Peroxide One-step Pulping and Bleaching Process

收稿日期：

DOI：10.11980/j.issn.0254-508X.2014.05.016

关键词: 棉短绒蒸煮蒸漂 H₂O₂ COD

Key Words:cotton linter cooking cooking and bleaching H₂O₂ COD

基金项目:

作者	单位
薛润林	南京义友自控仪表有限公司，江苏南京，210042

摘要点击次数: 5373

全文下载次数: 1814

摘要:现行棉短绒制浆采用H₂O₂一步法蒸漂制浆工艺，即棉短绒脱脂、去除木素、去疵点与H₂O₂氧化漂白同时进行，由于脱脂、去除木素、去疵点的最适宜温度与H₂O₂蒸漂不同，脱脂滞后于H₂O₂分解，降低了H₂O₂的利用率。本文分析了H₂O₂一步法蒸漂制浆的不足，并提出了3种改进措施，即采用二步法蒸漂制浆、混合蒸漂工艺及改进一步法蒸漂的升温曲线等，以提高H₂O₂的利用率，降低废水中的COD。

Abstract:The existing cotton linter hydrogen peroxide one-step pulping and bleaching process realized simultaneously degreasing and bleaching, however due to the difference of degreasing temperature and bleaching tempreature, it would cause low utilization rate of peroxide. This paper proposed to adorpt two-step process, in which cotton linter was degreased at first, then bleached with peroxide. This process could improve hydrogen peroxide utilization rate and reduce COD discharge.

查看全文 HTML 查看/发表评论下载PDF阅读器