|
二维码（扫一下试试看！） |
| 麦草生物化学机械法制浆废液的性能分析 |
| Performance Analysis of Wheat Straw Bio-chemimechanical Pulping Waste Liquor |
| 收稿日期：2022-02-01 |
| DOI：10.11980/j.issn.0254-508X.2022.10.008 |
| 关键词: 麦草 生物化学机械法制浆 废液 成分分析 |
| Key Words:wheat straw bio-chemimechanical pulping waste liquor component analysis |
| 基金项目:国家重点研发计划（2019YFC1905904）；浙江景兴纸业股份有限公司校企合作项目。 |
| 作者 | 单位 | 邮编 | | 李晨曦* | 天津科技大学轻工科学与工程学院,天津市制浆造纸重点实验室,天津,300457 | 300457 | | 范中秋 | 天津科技大学轻工科学与工程学院,天津市制浆造纸重点实验室,天津,300457 | 300457 | | 宋佳翼 | 天津科技大学轻工科学与工程学院,天津市制浆造纸重点实验室,天津,300457 | 300457 | | 邵学军 | 山东世纪阳光纸业集团有限公司,山东潍坊,262400 | 262400 | | 刘春兰 | 山东世纪阳光纸业集团有限公司,山东潍坊,262400 | 262400 | | 程正柏 | 浙江景兴纸业股份有限公司,浙江平湖,314214 | 314214 | | 曹海兵 | 天津科技大学轻工科学与工程学院,天津市制浆造纸重点实验室,天津,300457
浙江景兴纸业股份有限公司,浙江平湖,314214 | 314214 | | 徐柯 | 成都佰信维科技有限公司,四川成都,610000 | 610000 | | 刘洪斌 | 天津科技大学轻工科学与工程学院,天津市制浆造纸重点实验室,天津,300457 | 300457 | | 安兴业 | 天津科技大学轻工科学与工程学院,天津市制浆造纸重点实验室,天津,300457 | 300457 |
|
| 摘要点击次数: 1443 |
| 全文下载次数: 742 |
| 摘要:对麦草生物化学机械法制浆（Bio-CMP）各工段制浆废液的性能进行了定量分析。结果表明，麦草Bio-CMP各工段废液的固形物含量较低，属低浓废液。废液波美度和色度分别低于4.05（°Bé，20 ℃）和1064.39 C.U。与传统制浆方法相比，Bio-CMP废液COD偏高，总磷和总氮含量较低。废液总悬浮固体和溶解性固体分别在151~20730 mg/L和406~19080 mg/L之间。与其他工段废液相比，碱预处理后的废液电导率值及葡萄糖、木糖和阿拉伯糖含量最高。碱-酶协同预处理得到废液中的可溶性木质素含量最高。 |
| Abstract:The properties of waste liquor from each stage of wheat straw bio-chemimechanical pulping （Bio-CMP） process were quantitatively studied. The results showed that the wheat straw Bio-CMP waste liquor belonged to low concentration waste liquor with a low solid content of each stage. Baume degree and the color values of the waste liquor were lower than 4.05 （°Be， 20 ℃） and 1064.39 C.U.， respectively. Compared with traditional pulping method， the COD of Bio-CMP waste liquor was relatively higher， but with a lower total phosphorus and total nitrogen amount. The total suspended solids and dissolved solids of the Bio-CMP waste liquor were distributed in the range of 151~20730 mg/L and 406~19080 mg/L， respectively. Compared with those from other stages， the electrical conductivity and content of glucose， xylose and arabinose of the waste liquor obtained after caustic pretreatment possessed the highest value， While the soluble lignin content after alkali-enzyme synergistic pretreatment was the highest. |
| 查看全文 HTML 查看/发表评论 下载PDF阅读器 |
|
|
|