|
二维码（扫一下试试看！） |
| 竹浆硫酸盐法蒸煮预浸段硅溶出及抑制规律研究 |
| Research on Leaching and Restraining of Silicon in Pre-impregnation Stage of Bamboo Sulfate Cooking |
| 收稿日期： |
| DOI：10.11980/j.issn.0254-508X.2014.05.003 |
| 关键词: 竹浆 碱回收 留硅剂 溶出率 |
| Key Words:bamboo pulp alkali recovery silicon-restrainer agent leaching rate |
| 基金项目:本课题得到国家“十二五”科技支撑计划项目课题“高效竹材制浆造纸及其剩余物利用新技术研究与示范”（2012BAD23B02）、国家级大学生创新创业训练计划项目（201210708009）、国家自然科学基金（208-76092）、陕西科技大学学科带头人培育计划项目（20876092）的资助。 |
|
| 摘要点击次数: 4802 |
| 全文下载次数: 1652 |
| 摘要:高硅含量的竹材制浆给碱回收系统造成不利影响，且对白泥的回收利用带来很大的困难。结合贵州赤天化纸业有限公司汽-液两相双塔连续蒸煮器生产硫酸盐竹浆的生产工艺，对硫酸盐法蒸煮中预浸段硅的溶出规律及添加留硅剂对硅溶出的抑制效果进行了研究。研究发现，相同保温时间下，保温温度低于140℃时，硅的溶出速率较快且稳定，超过140℃，硅的溶出速率变慢，保温温度为100℃时，留硅剂对硅溶出的抑制效果最好；相同保温温度下，保温时间少于60 min时，硅的溶出量随时间的延长逐渐增加，60 min时，硅的溶出量达到最大，继续延长时间，硅的溶出量趋于稳定，保温时间在90~120 min时，留硅剂对硅溶出的抑制效果最好。 |
| Abstract:In kraft pulping, high silicon content of bamboo caused negative effects on the alkali recovery system and the recycling of lime mud. The leaching pattern of silicon and the prohibiting silicon from dissolving effect of the silicon restrainer in pre-impregnating stage were investigated based on the process of steam-liquid two phase two-tower continuous cooking using in Chitianhua Paper. The result showed that the leaching rate of silicon was rapid and stable under 140℃, while it was slow when the temperature was over 140℃. The silicon restrainer effect of prohibiting silicon from dissolving was the best when the temperature was 100℃. The dissolved silicon amount increased to the maximum in 60 min, and then became stable. The restraining effect of the restrainer was the best in 90~120 min. |
| 查看全文 HTML 查看/发表评论 下载PDF阅读器 |