本文二维码信息
二维码（扫一下试试看！）
卡伯值对麦草浆DQP漂白污染负荷影响的研究
The Effect of Kappa Number of Wheat Straw Unbleached Pulp on the Pollutants of Its DQP Bleaching Effluent
收稿日期：  
DOI：10.11980/j.issn.0254-508X.2013.02.008
关键词:  麦草  未漂浆  DQP漂白  卡伯值  CODCr  BOD5  AOX
Key Words:wheat straw  unbleached pulp  DQP bleaching  Kappa number  CODCr  BOD5  AOX
基金项目:
作者单位
刘　倩 中国制浆造纸研究院，北京，100102 
彭建军 中国制浆造纸研究院，北京，100102 
沈臻煌 中国制浆造纸研究院，北京，100102 
陈雪梅 中国制浆造纸研究院，北京，100102 
摘要点击次数: 5345
全文下载次数: 1642
摘要:使用同一卡伯因子对不同卡伯值的麦草未漂浆进行DQP漂白，研究污染负荷及浆料性能的变化情况。结果表明，漂白废水的CODCr、BOD5及AOX负荷随未漂浆卡伯值的降低而降低，漂白浆的白度随未漂浆卡伯值的降低而升高。未漂浆卡伯值每增加1个单位，DQP漂白废水CODCr负荷增加2.6 kg/t浆左右，BOD5负荷增加0.6 kg/t浆左右；AOX负荷均较低，为0.5~0.7 kg/t浆。未漂浆经DQP漂白后强度性能较好，且未漂浆卡伯值越高，漂白浆强度性能越好。
Abstract:Unbleached wheat straw pulps with different Kappa number were bleached by DQP bleaching sequence under the same Kappa factor, and the bleaching effluent load and pulp properties were evaluated. The results showed that the CODCr、BOD5 and AOX loads of the bleaching effluent became lower as the Kappa number of the unbleached pulp was lower, and at the same time the brightness of the bleached pulp became higher. And CODCr and BOD5 increased by about 2.6 kg/t pulp and 0.6 kg/t pulp respectively when Kappa number of the unbleached pulp increased each one unit; the AOX was in the range of 0.5~0.7 kg/t pulp, which was considerably lower than the AOX load of the traditional CEH bleaching. The paper strength was good after DQP bleaching, and the higher the Kappa number of unbleached pulp was, the better the paper strength properties were.
查看全文  HTML  查看/发表评论  下载PDF阅读器